Hyundai Ioniq: Brake System / Stop Lamp Switch. Troubleshooting

Hyundai Ioniq (AE) 2017-2024 Service Manual / Brake System / Brake System / Stop Lamp Switch. Troubleshooting

Troubleshooting
1.
Part diagnosis
Items
Cause
Symptom

Switch fuse
Faulty fuse connection, Damaged fuse
DTC Code : P0504
Symptom : Shifting gear trouble, Starting failure, Cruise control function cancelation trouble, EPB function cancelation trouble, Stop lamp lighting trouble, ESP OFF light illuminated.
① A waveform inspection is performed using an oscilloscope on each part during vehicle acceleration/braking. (Refer to stop lamp switch circuit inspection procedures)

② Refer to the relevant repair procedures of the part when something abnormal is discovered in the waveform (Refer to the repair procedures of the relevant part and if necessary replace it)
Relay fuse
Faulty fuse connection, Damaged fuse
DTC Code : P0504
Symptom : Shifting gear trouble, Starting failure, Cruise control function cancelation trouble, EPB function cancelation trouble, Stop lamp lighting trouble , ESP OFF light illuminated.
Stop lamp switch
Damaged wiring of each part
Faulty connection to connector
Each part is defective
DTC Code : P0504
Symptom : Shifting gear trouble, Starting failure, Cruise control function cancelation trouble, EPB function cancelation trouble, Stop lamp lighting trouble , ESP OFF light illuminated.
Stop signal electronic module (If it applies)
DTC Code : P0504, C2130, C2131
Symptom : Shifting gear trouble, Starting failure, Cruise control function cancelation trouble, EPB function cancelation trouble, Stop lamp lighting trouble , ESP OFF light illuminated.
Engine control module (ECM)
DTC Code : P0504
Symptom :Shifting gear trouble,Cruise control function cancelation trouble
Body control module (BCM)
Shifting gear trouble
Shift-lock solenoid
Shifting gear trouble
Inhibitor switch
Symptom : Shifting gear trouble, Starting failure, Cruise control function cancelation trouble, EPB function cancelation trouble
Smart Key Unit (SMK)
Starting failure
Electronic parking brake
Symptom : EPB function cancelation trouble , ESP OFF light illuminated.
ABS/VDC control module
(Pressure sensor)
Symptom : ESP OFF light illuminated.

2.
Symptom diagnosis
Symptom
Part that could be the cause

Trouble starting
Switch fuse, Relay fuse, Stop lamp switch, Stop signal electronic module, ABS/VDC control module, Each wire, Connector
① Inspect waveform using an oscilloscope on each part during vehicle acceleration/braking. (Refer to stop lamp switch circuit inspection Procedures)

② Refer to the relevant repair procedures of the part when something abnormal is discovered in the waveform (Refer to the repair procedures of the relevant part and if necessary replace it)
Trouble shifting gears
Switch fuse, Relay fuse, Stop lamp switch, Stop signal electronic module, BCM, ECM, Inhibitor switch, Each wire, Connector
ESP OFF light illuminated
Switch fuse, Relay fuse, Stop lamp switch, Stop signal electronic module, ABS/VDC control module, Each wire, Connector
P0504
Switch fuse, Relay fuse, Stop lamp switch, Stop signal electronic module, ECM, Each wire, Connector
Stop lamp does notworking
Switch fuse, Relay fuse, Stop lamp switch, Stop signal electronic module, Wire/Connector disconnected
Stop lamp always turns on
Stop lamp switch, Stop signal electronic module, Wiring short circuit, Damaged fuse

3.
Stop lamp switch system diagnosis

SSEM : Stop Signal Electronic Module
4.
Refer to DTC guide when the related DTC codes are displayed.

    Stop Lamp Switch. Repair procedures

    Removal1.Turn ignition switch OFF and disconnect the negative (-) battery cable.2.Remove the lower crash pad.(Refer to Body - "Crash Pad")3.Remove the knee airbag...

    Parking Brake System

    ..

    Other information:

    Hyundai Ioniq (AE) 2017-2024 Service Manual: General information


    Basic Service SymbolsThere are five primary symbols used to complement illustrations. These symbols indicate the part to apply such materials during service. Symbol Meaning Do not reuse the part. Replace a new one...

    Hyundai Ioniq (AE) 2017-2024 Owner's Manual: Securing a child restraint with lap/shoulder belt


    When not using the LATCH system, all child restraints must be secured to a vehicle rear seat with the lap part of a lap/shoulder belt. WARNING ALWAYS place a rear-facing child restraint in the rear seat of the vehicle. Placing a rear-facing child restraint in the front seat can result in serious injury or death if the child restraint is struck by an inflating air bag...

    Categories

    Tilt Steering / Telescope Steering

    Adjust the steering wheel so it points toward your chest, not toward your face. Make sure you can see the instrument cluster warning lights and gauges. After adjusting, push the steering wheel both up and down to be certain it is locked in position. Always adjust the position of the steering wheel before driving.

    WARNING

    NEVER adjust the steering wheel while driving. This may cause loss of vehicle control resulting in an accident.

    Hyundai Ioniq. Tilt Steering / Telescope Steering

    read more


     
    Copyright © 2024 www.hioniqae.com