Hyundai Ioniq: Body (Interior and Exterior) / Specifications

Hyundai Ioniq (AE) 2017-2024 Service Manual / Body (Interior and Exterior) / Specifications

Specifications

Items		Specification
Hood	Type	Front openine type, rear hinged, stay rod type
Front Door	Construction	Front hinged, frame door construction
	Regulator system	Wire drum type
	Locking system	Pin-fork system
Rear Door	Construction	Front hinged, frame door construction
	Regulator system	Wire drum type
	Locking system	Pin-fork system
Tailgate	Type	Front hinged, gas lifter type
Seat Belts	Front	3 point type with Emergency Locking Retractor (E.L.R)
Seat Belts	Rear	3 point type with Emergency Locking Retractor (E.L.R)

Tightening Torque

Items			N.m	Kgf.m	lb-ft
Front and rear doors	Door hinge to body		37.3 - 41.2	3.8 - 4.2	27.5 - 30.4
	Door hinge to door		21.6 - 26.5	2.2 - 2.7	15.9 - 19.5
	Door checker to door		3.9 - 5.9	0.4 - 0.6	2.9 - 4.3
	Door checker to body		16.7 - 21.6	1.7 - 2.2	12.3 - 15.9
	Door glass mounting bolt		8.8 - 11.8	0.9 - 1.2	6.5 - 8.7
	Outside handle base mounting bolt	Handle	2.0 - 2.9	0.2 - 0.3	1.4 - 2.2
	Outside handle base mounting bolt	Cover	7.8 - 10.8	0.8 - 1.1	5.8 - 8.0
	Door channel mounting bolts		3.9 - 5.9	0.4 - 0.6	2.9 - 4.3
	Door latch mounting bolts		7.8 - 14.7	0.8 - 1.5	5.8 - 10.8
	Door module mounting bolts		8.8 - 13.7	0.9 - 1.4	6.5 - 10.1
	Door striker mounting bolts		18.6 - 28.4	1.9 - 2.9	13.7 - 21.0
Tailgate	Tailgate hinge to body		21.6 - 26.5	2.2 - 2.7	15.9 - 19.5
	Tailgate hinge to tail gate		7.8 - 11.8	0.8 - 1.2	5.8 - 8.7
	Tailgate guide bumper screws		6.9 - 8.8	0.7 - 0.9	5.1 - 6.5
	Tailgate latch mounting bolts		6.9 - 10.8	0.7 - 1.1	5.1 - 8.0
	Tailgate striker mounting bolts		21.6 - 26.5	2.2 - 2.7	15.9 - 19.5
Hood	Hood hinge to body		21.6 - 26.5	2.2 - 2.7	15.9 - 19.5
	Hood hinge to hood		21.6 - 26.5	2.2 - 2.7	15.9 - 19.5
	Hood latch to body		7.8 - 11.8	0.8 - 1.2	5.8 - 8.7
Seat	Front seat mounting bolts		49.0 - 63.7	5.0 - 6.5	36.2 - 47.0
Seat	Rear seat mounting bolts		16.7 - 25.5	1.7 - 2.6	12.3 - 18.8
Seat belt	Height adjuster mounting bolts		39.2 - 53.9	4.0 - 5.5	28.9 - 39.8
	Front seat belt upper anchor mounting bolt		39.2 - 53.9	4.0 - 5.5	28.9 - 39.8
	Front seat belt pretensioner mounting bolt		39.2 - 53.9	4.0 - 5.5	28.9 - 39.8
	Rear seat belt lower anchor mounting bolts		39.2 - 53.9	4.0 - 5.5	28.9 - 39.8
	Rear center seat belt retractor mounting bolts		39.2 - 53.9	4.0 - 5.5	28.9 - 39.8
	Rear seat belt retractor mounting bolt		39.2 - 53.9	4.0 - 5.5	28.9 - 39.8
	Seat belt buckle mounting bolt		39.2 - 53.9	4.0 - 5.5	28.9 - 39.8
Outside rearview mirror	Outside rearview mirror mounting nuts		6.9 - 10.8	0.7 - 1.1	5.1 - 8.0
Fender	Fender panel mounting bolts		7.8 - 11.8	0.8 - 1.2	5.8 - 8.7
Wiper arm	Wiper arm mounting nuts		22.6 - 26.5	2.3 - 2.7	16.6 - 19.5
Sunroof	Sunroof mounting nuts		3.9 - 5.9	0.4 - 0.6	2.9 - 4.3
Sunroof	Sunroof mounting bolts		7.8 - 11.8	0.8 - 1.2	5.8 - 8.7
Rear spoiler	Rear spoiler mounting nuts		5.9 - 6.4	0.6 - 0.65	4.3 - 4.7

High voltage shut-off procedures

High Voltage Shut-off Procedures • Be sure to read and follow the "General Safety Information and Caution" before doing any work related with the high voltage system...

Special service tools

S..

Other information:

Hyundai Ioniq (AE) 2017-2024 Service Manual: Engine Control Module (ECM). Repair procedures

Removal • When replacing the ECM, the vehicle equipped with the immobilizer must be performed procedure as below.[In the case of installing used ECM]1)Perform "ECM Neutral mode" procedure with GDS.(Refer to Body Electrical System - "Immobilizer System")2)After finishing "ECM Neutral mode", perform "Key teaching" procedure with GDS...

Hyundai Ioniq (AE) 2017-2024 Owner's Manual: Resetting the Sunroof

The sunroof may need to be reset if the following conditions occur: - The battery is discharged or disconnected or the sunroof fuse has been replaced or disconnected - The sunroof control lever is not operating correctly To reset the sunroof, perform the following steps: 1...