Hyundai Ioniq (AE): Dual Clutch Transmission Assembly / Transmission Gear Oil. General information

Hyundai Ioniq (AE) 2017-2022 Service & Repair Manual / DCT(Dual Clutch Transmission) System / Dual Clutch Transmission Assembly / Transmission Gear Oil. General information

General Information

Check & Change intervals

Check & Replenishment

Change

Capacity

Oil specification

Normal Use

Severe Use

No check

No service required

120000 km
( 80000 miles)

1.6 - 1.7 L
(0.42 - 0.44 U.S gal., 1.69 - 1.79 U.S.qt., 1.41 - 1.49 lmp qt.)

API Service GL-4, SAE 70W

•	Recommended oil - H.K.SHELL : SPIRAX S6 GHDE 70W DCTF PLUS - SK : HK D DCTF TGO-10 PLUS

Severe usage is defined as

•	Driving in dusty, rough roads

•	Driving in areas using salt or other corrosive materials or in very cold weather

•	Driving in sandy areas

•	Driving in mountainous areas

•	Driving for patrol car, taxi, commercial car or vehicle towing

•	Driving over 170 Km

•	Driving in veavy traffic area over 90°F (32°C)

•	Driving in areas using salt or other corrosive materials or in very cold weather

•	Towing a trailer, or using a camper or roof rack

❮DCT (Dual Clutch Transmission). Repair procedures

Removal • Be sure to read and follow the "General Safety Information and Caution" before doing any work related with the high voltage system.

Transmission Gear Oil. Repair procedures❯

Inspection • In principle, the transmission oil is maintenance-free, and no exchange is required. 1.Park the vehicle on flat ground and turn off the engine.

Other information:

Hyundai Ioniq (AE) 2017-2022 Service & Repair Manual: Intake Actuator. Repair procedures

Inspection1.Turn the ignition switch OFF.2.Disconnect the intake actuator connector.3.Verify that the intake actuator operates to the fresh position when connecting 12V to terminal 3 and grounding terminal 4.Verify that the intake actuator operates to the recirculation position when connected in reverse.

Hyundai Ioniq (AE) 2017-2022 Service & Repair Manual: Rear Corner Radar Unit. Repair procedures

Removal1.Disconnect the negative (-) battery terminal.2.Remove the rear bumper.(Refer to Body - "Rear Bumper")3.Remove the rear corner radar unit (A) after loosening the mounting nuts. • Take care not to separate the bracket from rear bumper when removing the rear corner radar sensor.

Hyundai Ioniq (AE): Dual Clutch Transmission Assembly / Transmission Gear Oil. General information

Other information:

Hyundai Ioniq (AE) 2017-2022 Service & Repair Manual: Intake Actuator. Repair procedures

Hyundai Ioniq (AE) 2017-2022 Service & Repair Manual: Rear Corner Radar Unit. Repair procedures

Categories